I just finished evaluating the alcohol cleaned parts that you sent to me. The results as shown on the following page vary somewhat from part to part:
11 Fr. Spring- The alcohol did remove a good amount of the contamination, but it still does not look as good as the vapor degreased part. Data points were consistent with a low standard deviation.
J Pins- Looked like the alcohol soak cleaned better than the vapor degreaser. Data scatter was very high (notice the two readings in the low 100's).
Impeller Shaft- The shafts cleaned with alcohol after passivation came out with lower readings than parts that were only passivated (similar trend to the parts just alcohol soaked). As I mentioned before I would like to perform some FTIR readings on these parts. The software we need should be in next week (sorry about the delay).
Short Pins- Too small to obtain readings on the OSEE. I will use the FTIR to evaluate these when we get the necessary software.
| OSEE Results For C.R. Bard Inc.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Part #
|
1.01E+08
|
|
|
|
230056-0000
|
|
895-0019
|
|
|
| Lot #
|
13020707
|
|
|
|
13021720
|
|
|
3019101
|
|
|
| Desc.
|
1/8 Precision Ball
|
|
|
Impeller Plates
|
|
11 Fr. Stylet
|
|
| Status
|
Dirty
|
Vap Degr
|
IPA Soak
|
Dirty
|
Vap Degr
|
Alc. s&w
|
Alc. soak
|
Dirty
|
Vap Degr
|
|
|
|
77
|
95
|
90
|
272
|
343
|
970
|
446
|
198
|
197
|
|
|
|
63
|
111
|
87
|
327
|
485
|
755
|
416
|
208
|
213
|
|
|
|
84
|
112
|
104
|
385
|
511
|
904
|
563
|
169
|
210
|
|
|
|
70
|
113
|
102
|
270
|
397
|
678
|
506
|
215
|
202
|
|
|
|
98
|
120
|
101
|
214
|
402
|
512
|
590
|
152
|
194
|
|
|
|
51
|
101
|
85
|
248
|
553
|
734
|
609
|
141
|
202
|
|
|
|
69
|
117
|
96
|
281
|
468
|
850
|
848
|
137
|
198
|
|
|
|
79
|
103
|
93
|
267
|
375
|
494
|
516
|
124
|
205
|
|
|
|
|
107
|
91
|
263
|
668
|
967
|
|
153
|
191
|
|
|
|
|
106
|
|
242
|
387
|
969
|
|
136
|
208
|
|
| Average
|
73.88
|
109.00
|
94.75
|
276.90
|
458.90
|
783.30
|
561.75
|
163.30
|
202.00
|
|
| Std
|
14.15
|
8.54
|
7.17
|
47.82
|
99.31
|
180.65
|
133.53
|
32.69
|
7.12
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Part #
|
|
868-0001
|
|
868-0002
|
|
|
|
23006000
|
|
|
| Lot #
|
|
4161103
|
|
|
|
|
|
5318102
|
|
|
| Desc.
|
|
11 Fr. Spring
|
9 Fr. Spring
|
|
|
Impeller Shaft
|
|
| Status
|
Dirty
|
Vap Degr
|
Alc. Soak
|
Dirty
|
Dirty
|
Vap Degr
|
Pass
|
Pas & Alc
|
Alc. soak
|
Alc. s&w
|
|
|
125
|
138
|
136
|
256
|
158
|
194
|
138
|
158
|
83
|
105
|
|
|
118
|
155
|
146
|
288
|
151
|
198
|
173
|
157
|
121
|
88
|
|
|
114
|
157
|
157
|
302
|
87
|
182
|
140
|
167
|
115
|
75
|
|
|
121
|
198
|
156
|
258
|
144
|
184
|
153
|
124
|
114
|
74
|
|
|
111
|
165
|
142
|
234
|
133
|
203
|
138
|
124
|
108
|
83
|
|
|
117
|
157
|
149
|
218
|
158
|
203
|
217
|
120
|
121
|
103
|
|
|
109
|
255
|
139
|
181
|
109
|
190
|
154
|
140
|
118
|
87
|
|
|
130
|
204
|
133
|
227
|
164
|
182
|
188
|
141
|
118
|
88
|
|
|
124
|
186
|
147
|
206
|
178
|
196
|
167
|
123
|
|
|
|
|
130
|
156
|
152
|
223
|
127
|
181
|
|
|
|
|
| Average
|
119.90
|
177.10
|
145.7
|
239.30
|
140.90
|
191.30
|
163.11
|
139.33
|
112.25
|
87.88
|
| Std
|
7.40
|
34.52
|
8.17
|
37.03
|
27.46
|
8.71
|
26.50
|
17.82
|
12.56
|
11.37
|